568 F2d 284 American Iron and Steel Institute v. Environmental Protection Agency

568 F.2d 284

10 ERC 1689, 7 Envtl. L. Rep. 20,738

AMERICAN IRON AND STEEL INSTITUTE, Armco Steel Corporation,
Bethlehem Steel Corporation, Inland Steel Company, Jones &
Laughlin Steel Corporation, National Steel Corporation,
Republic Steel Corporation, United States Steel Corporation,
Wheeling-Pittsburgh Steel Corporation, Petitioners,
v.
ENVIRONMENTAL PROTECTION AGENCY, Respondent.
SIERRA CLUB, Petitioner,
v.
ENVIRONMENTAL PROTECTION AGENCY, and Russell E. Train,
Administrator, Respondents,
Youngstown Sheet and Tube Company, Republic Steel
Corporation, United States Steel Corporation, Intervenors.
COMMONWEALTH OF PENNSYLVANIA, DEPARTMENT OF ENVIRONMENTAL
RESOURCES, Petitioner,
v.
ENVIRONMENTAL PROTECTION AGENCY, Respondent,
Youngstown Sheet and Tube Company, Republic Steel
Corporation, United States Steel Corporation, Intervenors.
ALLEGHENY LUDLUM INDUSTRIES, INC., Atlantic Steel Company,
the Babcock& Wilcox Company, Continental Copper & Steel
Industries, Inc., Crucible Inc., Cyclops Corporation,
Detroit Steel, Interlake, Inc., Lone Star Steel Company,
Shanango Incorporated, Sharon Steel Corporation, the Timken
Company, Petitioners,
v.
ENVIRONMENTAL PROTECTION AGENCY, Respondent.
YOUNGSTOWN SHEET AND TUBE COMPANY, Petitioner,
v.
ENVIRONMENTAL PROTECTION AGENCY and Russell E. Train,
Administrator, Respondents.
CF & I STEEL CORPORATION, Petitioner,
v.
ENVIRONMENTAL PROTECTION AGENCY, Respondent.

Nos. 76-1386, 76-1749, 76-1751, 76-1757, 76-2176 and 76-2232.

United States Court of Appeals,
Third Circuit.

Argued May 2, 1977.
Final Submission Aug. 17, 1977.
Decided Sept. 14, 1977.

William C. Robb, Welborn, Dufford, Cook & Brown, Denver, Colo., for petitioner in No. 76-2232, CF & I Steel Corp.

Douglas R. Blazey, Maxine T. Woelfling, Harrisburg, Pa., for petitioner in No. 76-1751, Com. of Pa.

Jerome S. Kalur, Weston, Hurd, Fallon, Sullivan & Paisley, Cleveland, Ohio, for petitioner in No. 76-1749, Sierra Club.

Barry L. Malter, Environmental Protection Agency, Washington, D. C., and Raymond W. Mushal, Dept. of Justice, Land and Natural Resources Div., Washington, D. C., for respondents.


Advertisement
view counter
1

William W. Falsgraf, Baker, Hostetler & Patterson, Cleveland, Ohio, for intervenor, Youngstown Sheet and Tube Co., in Nos. 76-1749 and 76-1751.

2

Patrick F. McCartan, Jones, Day, Reavis & Pogue, Cleveland, Ohio, for intervenor, Republic Steel Corp., in Nos. 76-1749 and 76-1751.

3

John McN. Cramer, Reed, Smith, Shaw & McClay, Pittsburgh, Pa., for intervenor, U. S. Steel Corp., in Nos. 76-1749 and 76-1751.

4

David McNeil Olds, Blair S. McMillin, Thomas C. Wettach, Thomas J. Duman, Reed, Smith, Shaw & McClay, Pittsburgh, Pa., David S. Watson, Peter G. Veeder, Frank J. Clements, Thorp, Reed & Armstrong, Pittsburgh, Pa., Max N. Edwards, Richard E. Schwartz, Collier, Shannon, Rill, Edwards & Scott, Washington, D. C., for petitioners in Nos. 76-1386, 76-1757 and 76-2176, American Iron & Steel Institute, Allegheny Ludlum Industries and Youngstown Sheet & Tube Co. et al.

5

Henry H. Korn, Richard E. Nolan, Davis, Polk & Wardwell, New York City, for American Iron & Steel.

6

Albert J. Slap, Public Interest Law Center of Philadelphia, Philadelphia, Pa., for petitioner, Sierra Club; John D. Hoffman, Sierra Club Legal Defense Fund, Inc., San Francisco, Cal., of counsel, Jerome S. Kalur, Weston, Hurd, Fallon, Sullivan & Paisley, Cleveland, Ohio, for petitioner, Sierra Club.

7

William W. Falsgraf, Evan Jay Cutting, H. Stephen Madsen, Baker, Hostetler & Patterson, Cleveland, Ohio, Donald J. Libert, Youngstown, Ohio, for intervenor, Youngstown Sheet and Tube Co.


Advertisement
view counter
8

David W. Furgason, William C. Robb, Welborn, Dufford, Cook & Brown, Denver, Colo., for petitioner CF & I Steel Corp.

9

Ray E. McDevitt, Washington, D. C., Alfred T. Ghiorzi, Peter R. Taft, Edmund B. Clark, Raymond W. Mushal, Chief Appellate Section, Dept. of Justice, Land and Natural Resources Div., Washington, D. C., for respondents E.P.A.

10

Patrick F. McCartan, Marc L. Swartzbaugh, Cleveland, Ohio, for Republic Steel Corp.; Jones, Day, Reavis & Pogue, E. P. Weber, Jr., James D. Donohoe, Cleveland, Ohio, of counsel.

11

K. Robert Conrad, Charles J. Bloom, Pepper, Hamilton & Scheetz, Philadelphia, Pa., for CF & I Steel Corp.

OPINION OF THE COURT

12

Before SEITZ, Chief Judge, ROSENN, Circuit Judge and MEANOR, District Judge.*

13

SEITZ, Chief Judge.

14

These are petitions to review Environmental Protection Agency regulations governing certain manufacturing processes within the iron and steel industry. The regulations, which were published in the Federal Register on March 29, 1976, establish maximum permissible quantities of pollutant which may be discharged by operations performing the designated processes. The regulations also survey the available pollution control techniques, and specify techniques the "best practicable control technology currently available" (BPCTCA) which might be used in meeting the prescribed effluent limitations. In issuing the regulations, the EPA was exercising its statutory mandate to establish effluent limitations requiring the application of the BPCTCA by July 1, 1977. 33 U.S.C. § 1311(b)(1)(A). It is these regulations as to BPCTCA which are under review here. The regulations promulgated by the EPA also contain proposed : a) effluent limitations and guidelines as to the application of the "best available technology economically achieveable" by July 1, 1983 b) standards of performance for new point sources and c) pretreatment standards for existing sources and for new sources.

15

The regulations governing the application of the BPCTCA are in "interim final" form, which is to say that, while they were to take effect immediately upon promulgation, the EPA is now in the process of considering "final" regulations covering the same subject matter. The regulations state that the reasons for this novel procedural form is that "(t)he Agency is subject to an order of the United States District Court for the District of Columbia entered in Natural Resources Defense Council v. Train, et al. (Cv.No.1609-73) which requires the promulgation of regulations for this industry category no later than March 15, 1976." 41 Fed.Reg. 13004.

16

The regulations deal only with certain processes of the iron and carbon steel and specialty steel (ferroalloy and stainless steel) industries, namely forming and finishing processes, and with certain steelmaking processes within the specialty steel industry. An earlier phase ("phase I") of the regulations, published on June 28, 1974, dealt with steelmaking processes within the iron and carbon steel industries. This court considered the latter regulations in American Iron and Steel Institute v. EPA (AISI I), 526 F.2d 1027 (3d Cir. 1975), and remanded them to the EPA for reconsideration in certain respects.

I.

17

Some petitioners have argued that the "interim final" regulations are invalid because they were not promulgated in accordance with the Administrative Procedure Act. The relevant procedural history may be outlined as follows.

18

Since November 15, 1973, the EPA has been under order of the district court for the District of Columbia, in Natural Resources Defense Council v. EPA to promulgate regulations governing the processes of the iron and steel industry covered by the present regulations. The EPA was originally under order to promulgate these regulations in 1974, but it has asked for and received several extensions of the deadlines.

19

On August 21, 1975, the EPA published in the Federal Register "advance notice of intent to propose and promulgate effluent limitations and guidelines for existing sources." 40 Fed.Reg. 36708. The notice of "proposed rulemaking" (ANPR) then proceeded to list the subcategories of the industry for which tentative regulations were being set forth. The EPA engaged in extensive reevaluation and revision of the tentative limitations and guidelines after they were published, partly in response to substantial sentiment within the agency that they were too lenient. The EPA did not, however, propose the revised regulations for further notice and comment. It also stipulated that the interim final regulations would be effective immediately, and thus did not allow the 30 day interval between publication date and date of effectiveness usually required by the APA. 5 U.S.C. § 553(d). The regulations contain a statement that, due to the pendency of the court order and the need to expedite the effectuation of the Act, the Agency had determined that it was "impracticable and contrary to the public interest" "to develop and publish regulations . . . in proposed form (and) to provide a 30 day comment period." The Agency also stated that there was "good cause . . . for these regulations to become effective immediately upon publication." 41 Fed.Reg. 13004.

20

Petitioners in Nos. 76-1386, 76-1757 and 76-2176, ("the Companies") who are steel companies and the American Iron and Steel Institute have made two challenges to the validity of the "interim final" regulations under the APA which require discussion.1

21

They first argue that any regulations governing specialty steel are invalid because the ANPR failed to give sufficient indication that the Agency was considering regulations as to the specialty steel segment of the industry. This court delineated the purposes of the APA's notice and comment requirement in Texaco, Inc. v. FPC, 412 F.2d 740, 744 (1969): "Section 553 was enacted to give the public an opportunity to participate in the rule-making process. It also enables the agency promulgating the rule to educate itself before establishing rules and procedures which have a substantial impact on those regulated." In evaluating the Companies' contention that the ANPR was insufficient to enable the public to effectively participate in the rule-making process, we must determine whether the notice given was "sufficient to fairly apprise interested parties" of all significant subjects and issues involved. Senate Rept. No. 752, 79th Congress, 1st Session, at 16 (1945).

22

The adequacy of the notice as to specialty steel really encompasses two questions: whether there was adequate notice that the making of specialty steel would be covered by the regulations, and whether there was adequate notice that the forming and finishing of specialty steel would be covered by the regulations. With respect to the forming and finishing of specialty steel, the ANPR set forth "Proposed Effluent Guidelines and Standards" for the "Iron and Steel Manufacturing Point Source Category." As noted above, the EPA was making regulations under order of the court in Natural Resources Defense Council v. EPA. In ordering the EPA to make regulations, the court listed various "categories": while category 19 was "Iron and Steel Manufacturing", category 23 was "Ferroalloy Manufacturing" what we have called specialty steel. Thus, an interested person who read that the EPA was giving advance notice of intent to promulgate regulations for the "Iron and Steel Manufacturing Point Source Category" would be misled into thinking that regulations for "Ferroalloy Manufacturing" were not involved. This misimpression would be fostered by the fact that the ANPR said that "(i)n developing the requisite data to support effluent limitations, guidelines and standards EPA commissioned a study and report entitled 'Development Document for Effluent Limitations Guidelines and New Source Performance Standards Iron and Steel Industry: Hot Forming and Cold Finishing Segment' prepared by Cyrus Wm. Rice Division, NUS Corporation." The EPA had commissioned an entirely separate study of the specialty steel industry by Datagraphics, Inc.

23

Our conclusion that the ANPR would not apprise an interested person that the specialty steel industry would be covered by the regulations on forming and finishing processes applies a fortiori with respect to the portions of the interim final regulations which deal with the making of specialty steel. The ANPR gave no indication that the Agency intended to make any regulations on steelmaking, whether in the carbon steel or specialty steel industry: all the enumerated subcategories of the "iron and steel manufacturing" industry pertained to processes other than steelmaking. The interim final regulations, however, do contain regulations governing three processes by which specialty steel is made.2 Since the ANPR gave no indication that the regulations would deal with steelmaking, an interested person would not be able to make comments which could assist the EPA in formulating these regulations.

24

EPA argues that even if the ANPR was insufficient to apprise an interested person that specialty steel would be covered by the regulations, the regulations may be upheld under an exception to the APA's notice and comment requirement. 5 U.S.C. § 553(b) says that:

25

"General notice of proposed rule making shall be published in the Federal Register . . . . Except when notice or hearing is required by statute, this subsection does not apply . . . (b) when the agency for good cause finds . . . that notice and public procedure are impracticable, unnecessary, or contrary to the public interest."

26

This exception is to be narrowly construed. As is stated in the Senate Report on a precursor of the final APA:

27

"Impracticable" means a situation in which the due and required execution of the agency functions would be unavoidably prevented by its undertaking public rule-making proceedings . . . "Public interest" supplements the terms "impracticable" or "unnecessary"; it requires that public rule-making procedures shall not prevent an agency from operating and that, on the other hand, lack of public interest in rule making warrants an agency to dispense with public procedure. Senate Rept. No. 752, 79th Congress, 1st Session at 16. (1945)

28

In arguing that it was "impracticable and contrary to the public interest" to provide notice and an opportunity for comment, the EPA relies chiefly on the fact that it had been ordered to promulgate regulations by March 15, 1976 by the court in Natural Resources Defense Council v. EPA. But we find this argument unconvincing. The EPA had been under order to promulgate regulations for the specialty steel industry since November 15, 1973, and it received its contractor's study of the specialty steel industry in January, 1974. So EPA was aware of the necessity for rapid promulgation of the limitations on specialty steel in November of 1973, and had the basic contractor's study in January of 1974. But the interim final regulations were not published until March of 1976. Moreover, the ANPR did in fact contain detailed tentative regulations on the forming and finishing of iron and carbon steel, a subject on which EPA had obtained its contractor's report in July of 1974 6 months after it received its contractor's report on the carbon steel industry. Under these conditions, EPA has failed to show that it may be exempted from the APA's usual requirement of notice and comment.

29

In sum, EPA may not be exempted from the APA's rulemaking requirement of notice and comment, and it has failed to give adequate notice that the interim final regulations would govern the specialty steel industry.3 The interim final regulations are thus invalid insofar as they apply to the specialty steel industry.4

30

Apart from their challenge to the regulations concerning specialty steel, the Companies also allege that the ANPR did not give sufficient indication of the following two issues: "(1) whether filtration and tight recycle (the '10/10/5 model') are practicable for the steel industry to construct and operate by July 1, 1977 and (2) if so, the treatment levels achievable by such technology." The history behind the adoption of the 10/10/5 model is as follows. After the ANPR was published, the EPA, in its internal review of the tentative regulations found that:

31

"there were substantial errors in the limitations. The advance notice was improperly biased; costing inaccuracies caused an invalid comparison between clarifier and filter technologies; plants had already installed both filtration and recycle technology; and, generally, both BPT and BAT were set at improperly low levels, levels at which a quarter of the Nation's steel production would already be at BAT, with many more facilities at BPT . . ." EPA's Brief at 90.

32

The Agency's response was to make the regulations substantially more stringent. The Companies especially question the use of "filtration and tight recycle" technology, which is used in Subparts M (hot forming-primary subcategory), N (hot forming-section subcategory), O (hot forming-flat subcategory and P (pipe and tubes subcategory).5

33

We agree with the court in International Harvester Co. v. Ruckelshaus, 155 U.S.App.D.C. 411, 428, 478 F.2d 615, 632 n.51 (1973), that the submission of a proposed rule for comment does not of necessity bind an agency to undertake a new round of notice and comment before it adopts a rule which is different even substantially different from the proposed rule. As we have noted above, the adequacy of the notice must be tested by determining whether it would fairly apprise interested persons of the "subjects and issues" before the Agency.

34

Judged by this standard, we conclude that the ANPR was sufficient to apprise interested persons of the issues involved in the EPA's decision to adopt more stringent treatment technologies than had been embodied in the ANPR. The Companies' concern is focussed on the EPA's determination that recycling and filtration technology is BPCTCA with respect to some forming and finishing subcategories. These techniques, as we have noted, are prescribed as BPCTCA for Subparts M through P of the industry, and the control technology specified for these subcategories is similar. The chief pollutants produced by all four processes are suspended solids, oil and grease. The interim final regulations specify that the first step of the BPCTCA for all four processes is a primary scale pit a settling unit with oil skimming equipment applied to the effluent in the scale pit. This was also specified as the first step of the BPCTCA in the ANPR. The interim final regulations specify that after the scale pit,6 part of the effluent is recycled for use in the steel making process; this is one of petitioners' points of concern. The interim final regulations state that the remaining effluent in the scale pit goes to a clarifier; the use of a clarifier was also specified in the ANPR. The underflow from the clarifier is to be vacuumed filtered, as the ANPR had also stated. Finally, the overflow from the clarifier is filtered and discharged. The use of filtration is a second point of concern to petitioners, and is peculiar to the interim final regulations.

35

We conclude that the ANPR was sufficient to apprise interested persons that there was an issue as to whether recycling of partially clarified effluent was BPCTCA. In the first place, the suggested BPCTCA in the ANPR regulations for three of the four subcategories of the industry here involved N, O and P include some recycling of effluent. Moreover, in surveying the treatment technology currently in place in existing plants, the ANPR notice mentioned recycling with respect to all subcategories of the iron and steel industry for which the interim final regulations later specified recycling as part of the BPCTCA. An interested person thus should have been aware that recycling was potentially a significant component of the ultimate regulations as to BPCTCA.

36

The use of filtration upon the overflow from the clarifier presents a closer question, since the ANPR did not suggest that filtration of the clarifier overflow would be part of the BPCTCA for any of the hot-forming subcategories (Subparts M, N and O) or the pipe and tubes subcategory (Subpart P). Nevertheless, we conclude that the notice was sufficient, since, as with the use of recycle, the ANPR did inform the public that high rate filtration technology was already in place in plants in those of three subcategories (M, N and O). With respect to the meaning of BPCTCA, the Senate Report to the bill which ultimately became the Federal Water Pollution Control Act Amendments of 1972 said that: "(T)he Administrator should establish the range of best practicable levels based upon the average of the best existing performance by plants of various sizes, ages, and unit processes within each industrial category."7 Senate Report No. 92-414, 92d Congress, 1st Session (1971), p. 50. The statements in the ANPR that "a few plants will have high rate filters to treat either scale pit or clarifier effluents",8 and that the "range of treatment technology currently practiced in existing plants includes all the items discussed above"9 including the use of high rate filters may not be a full statement that the plants now employing filter technology within each subcategory of the industry are "of various sizes (and) ages." But this is little more than to say that EPA had not yet determined that filtration was BPCTCA when it published the August notice. The notice does fairly apprise interested parties that there was an issue as to whether filtration was BPCTCA because it states that some of the best existing plants use filters.

37

In sum, we conclude that the use of the 10/10/5 model did not violate the APA's requirement of notice and hearing.10

38

Pennsylvania's Department of Environmental Resources, ("Pennsylvania") the Petitioner in No. 76-1751, questions the sufficiency under the APA of the Agency's decision to exempt plants in the Mahoning River Valley region of Eastern Ohio "from the effluent limitations based on best practicable control technology currently available." We need discuss only two of Pennsylvania's arguments:11 1) that the EPA did not provide notice and an opportunity for comment on the special treatment afforded plants in the Mahoning Valley 2) that adequate judicial review of the Mahoning Valley exemption is precluded by the EPA's failure to include a "concise general statement of (the) basis and purpose" of the action as required by the APA. 5 U.S.C. § 553(c).

39

1. The interim final regulations state that:

40

The relief granted from severe economic impact in the Mahoning River Valley region, which impact is likely to occur absent such relief, is the exemption of point sources located within that region from the effluent limitations based on best practicable control technology currently available. Nevertheless, the Agency fully expects that authorities granting permits, pursuant to section 402 of the Federal Water Pollution Control Act, as amended, shall not allow point sources in that region to discharge pollutants in any greater amounts than are currently being discharged by those sources. 41 Fed.Reg. 12995.

41

The only indication in the ANPR that such an action might be taken is the following:

42

One commenter has claimed that the proposed guidelines will result in the loss of 12,000 jobs from the steel employment in the Mahoning River Valley region. Furthermore, the commenter asserts that "there is ample justification for adding to the guidelines, a subcategory based on the age of the facility."

43

The Agency intends to secure and evaluate additional information on possible economic impacts in this region and would consider revision of the regulations if the information appears to warrant this action. 40 Fed.Reg. 36723.

44

Pennsylvania argues that in reading the language "would consider revision of the regulations" an interested member of the public might well come to the conclusion that the EPA would not consider whether to give Mahoning Valley special treatment until the rulemaking then noticed had already been completed. Thus, the public could well have been misled into thinking that comments on the Mahoning Valley question were not appropriate during the present rulemaking proceedings.

45

Pennsylvania's argument hinges on the meaning of the word " regulations" in the ANPR. If the word refers to the regulations to be promulgated at the end of the noticed rulemaking, then a member of the public might indeed be misled into thinking that he should defer comment on the Mahoning Valley question. On the other hand, if the word refers to the regulations then proposed, a member of the public would be on notice that immediate comment was appropriate. We note that the ANPR states that "(t)he regulations set forth below when promulgated will amend 40 CFR, part 420." 40 Fed.Reg. 36708 (emphasis added). This, read in conjunction with the statement that the EPA would consider revision of the "regulations" to take account of any special conditions in the Mahoning Valley would indicate that immediate comment was appropriate. Thus, we conclude that there was sufficient notice to "fairly apprise" the public that the Agency might afford special treatment to facilities in the Mahoning Valley. We confess, however, that the language in the ANPR is hardly a model of clarity.

46

2. Pennsylvania has also argued that the Mahoning Valley exemption is invalid because the EPA did not give a "concise general statement of (the) basis and purpose" of the action as required by the APA. 5 U.S.C. § 553(c). This argument is meritless. The interim final regulations state that:

47

Tentative analysis of the available data leads to the conclusion that conditions in the Mahoning River Valley region are unique with respect to the physical and geographical characteristics of the region, physical and operating characteristics of the facilities located therein, and the importance of the facilities to the economy of the region. Tentative analysis of the available data and the consultant's evaluation thereof appears to support the contention that mandatory compliance with effluent limitations guidelines which do not take into account these factors is likely to result in severe economic dislocation within the Mahoning River Valley region.

48

In addition to similar economic disadvantages resulting from age and size characteristics, facilities in the region appear to share economic disadvantages caused by locational characteristics. These include the movement of markets away from the region, constrained access to raw materials due to the unavailability of waterborne transportation and required transshipment by rail, and space limitations which prohibit major expansion of existing facilities. 41 Fed.Reg. 12994.

49

This statement is clearly sufficiently detailed to allow for "searching judicial scrutiny." Amoco Oil v. EPA, 163 U.S.App.D.C. 162, 179, 501 F.2d 722, 739 (1974).

II.

50

We now turn to the issues raised by the various petitioners as to whether the EPA has properly carried out its functions under the Water Pollution Control Act. The Companies argue that the regulations are invalid because they specify only a maximum permissible level of effluent discharge, and do not indicate a range of permissible effluent levels by providing guidelines as to how much more severe controls may be required of any particular plant by the authority granting a pollution discharge permit under § 402 of the FWPCA. The argument thus raises questions as to the proper relation between § 301, which is the Agency's authority for promulgating specific effluent limitations requiring application of BPCTCA, and § 304, which directs the Agency to "specify factors to be taken into account in determining the control measures and practices applicable to point sources."

51

The Companies rely chiefly on this court's decision in AISI I which held EPA's regulations on iron and carbon steelmaking processes invalid because they failed to provide guidelines "to guide the permit-issuing authorities in deciding whether, and by how much, the limitation to be applied to any individual point source is more stringent than the base level." 526 F.2d at 1045. Since briefing and oral argument in this case, however, the panel in the earlier case has granted a motion to recall its mandate, and has held that the EPA may specify a maximum permissible level of effluent discharge without providing guidelines as to how permit issuers are to select more stringent levels of control. American Iron and Steel Institute v. EPA, slip opinion (July 29, 1977). This court now stands with the other courts of appeals which have considered this question. See Hooker Chemicals v. Train, 537 F.2d 620 (2d Cir. 1976); American Frozen Food Institute v. Train, 176 U.S.App.D.C. 105, 539 F.2d 107 (1976); FMC Corporation v. Train, 539 F.2d 973 (4th Cir. 1976); American Petroleum Institute v. E. P. A., 540 F.2d 1023 (10th Cir. 1976).

52

The holding of the prior panel on the motion to recall its mandate is binding upon us, and requires that we reject contentions. Consequently, we need not engage in any discussion of the merits of these contentions.

III.

53

The Companies have also argued that EPA did not properly evaluate the costs and benefits relevant to identifying the BPCTCA. In evaluating these arguments, we must follow the familiar12 standards governing judicial review of agency action under the APA. § 706 of the APA provides that "(t)he reviewing court shall hold unlawful and set aside agency action, findings, and conclusions found to be . . . arbitrary, capricious, an abuse of discretion, or otherwise not in accordance with law . . ." As the Supreme Court said in Citizens to Preserve Overton Park v. Volpe, 401 U.S. 402, 415, 91 S.Ct. 814, 823, 28 L.Ed.2d 136 (1971), an agency's "decision is entitled to a presumption of regularity. (citations omitted). But that presumption is not to shield (its) action from a thorough, probing, in-depth review." In conducting this review, we will not overturn agency action because the underlying reasoning is not fully set forth, if we can fairly discern the basis for the action. Bowman Transportation, Inc. v. Arkansas-Best Freight System, Inc., 419 U.S. 281, 285-6, 95 S.Ct. 438, 42 L.Ed.2d 447 (1974). But the touchstone of our review, both as to the Agency's consideration of the issues and the factual predicates of this consideration must be the administrative record. In deciding to accept or reject petitioners' contentions we must look "to the record that was considered by the agency not to post hoc rationalizations of counsel or even agency members and not to evidentiary materials that were not considered by the agency." Dry Color Mfrs. Assn., Inc. v. Department of Labor, 486 F.2d 98, 104 n.8 (3d Cir. 1973).

54

Section 304(b) of the FWPCA, as amended, states that, in assessing the BPCTCA, the EPA must consider:

55

. . . the total cost of application of technology in relation to the effluent reduction benefits to be achieved from such application, and shall also take into account the age of equipment and facilities involved, the process employed, the engineering aspects of the application of various types of control techniques, process changes, non-water quality environmental impact . . ., and such other factors as the Administrator deems appropriate.

56

As this court noted in AISI I, Senator Muskie, the Chairman of the Senate Subcommittee on Air and Water Pollution, stated in support of the House-Senate Conference Committee Report:

57

. . . The balancing test between total cost end effluent reduction benefits is intended to limit the application of technology only where the additional degree of effluent reduction is wholly out of proportion to the costs of achieving such marginal level of reduction for any class or category of sources.

58

The Conferees agreed upon this limited cost-benefit analysis in order to maintain uniformity within a class and category of point sources subject to effluent limitations and to avoid imposing on the Administrator any requirement to consider the location of sources within a category or to assess water quality impact of effluent controls, or to determine the economic impact of controls on any individual plant in a single community.13

59

Another factor which lead the court in AISI I, 526 F.2d at 1052, to conclude that "the Administrator must have broad discretion in weighing the costs and benefits" is the following passage from the Senate Report which discusses § 302 of the Act where a more specific cost-benefit analysis is required than with § 304:

60

The Committee recognizes that no mathematical balance can be achieved in considering relative costs and benefits nor would any precise formula be desirable, but in each case the Administrator or the State will be able to determine whether there is any reasonable connection at all between the costs which a particular effluent limitation would impose and any benefits (including the attainment of natural water quality) which might be derived.14

61

1. The Companies have argued that the interim final regulations are invalid because the EPA failed to reach any final conclusion as to whether the costs of compliance are justified by the benefits. But the record shows that the EPA did investigate the harmful effects of the various pollutants from iron and steel facilities. Moreover, the Agency calculated the contribution of selected additional levels of technology to eliminating the discharge of the various pollutants, and compared this contribution to the costs of these technologies. The Companies claim that this procedure was an "intellectual fraud" since, as the Agency expressly warned, inferences could not be drawn as to the cost-effectiveness of levels of treatment other than those which the Agency had selected to present. But given the EPA's "broad discretion" in weighing costs and benefits, and the fact that the Agency did evaluate several treatment technologies within each category, we conclude that the regulations are not invalid on the grounds that the Agency did not properly evaluate the cost effectiveness of possible treatment technologies.

62

2. The Companies have also argued that the EPA failed to properly consider the factors relevant to determining how the iron and steel industry should be broken down into subcategories, prior to identifying the BPCTCA for each subcategory. EPA's methodology may be described as follows. The Agency took a survey of existing treatment facilities and their performances to develop a list of the best plants: the list was ultimately narrowed to 68 plants with 111 operations of various ages, sizes, unit processes and in-place treatment technologies. The industry was studied "for the purpose of determining whether separate limitations are appropriate for different segments within the category." 41 Fed.Reg. 12990. The following factors were considered in determining possible subcategorization of the industry: manufacturing processes and equipment, products, raw materials, wastewater characteristics, waste treatability, gas cleaning equipment, size and age, land availability (location), and process water usage. The EPA ultimately determined that "(t) he individual processes, products, and the wastewater characteristics comprise the most significant factors in the categorization"15 of the industry, but also concluded that some of the other factors were helpful in supporting its subcategorization on the basis of the above factors. For example, with respect to the relevance of process water usage, the interim final regulations state that:

63

Examination of the available data indicates that within well defined ranges process water usage can be directly correlated to the various manufacturing operations. This correlation verifies the basis of the subcategorization scheme by manufacturing processes. Differences in scale (see size factor) of a categorized manufacturing process was considered. The results indicated that on a per ton of steel basis, process water usage is not dependent upon the scale of the manufacturing operation. It was observed though, that much larger volumes of process cooling water are generally required to cool the hot forming machinery than that which is needed for the cold forming operations, thus further substantiating the subcategorization by manufacturing process.

64

Considerations of age, location and raw materials revealed no discernible differences in process water usage. Process water usage parallels the subcategorization by final product considerations (see final products factor) where data revealed that for particular product requirements well defined manufacturing processes must be employed. 41 Fed.Reg. 12993-4.

65

On the other hand, the EPA found that some of the factors considered were not useful bases for subcategorization. As to size and age, the interim final regulations state:

66

Plant size and age, per se, are not viable factors for subcategorization of the iron and steel industry. Information compiled during this study and previous steel industry investigations do not reveal any discernible relationship between these factors and raw waste loads, effluent quality, treatability, or any other basis for subcategorization.

67

Although specialty steel plants do tend to be smaller than carbon steel plants, the type of steel produced has a greater impact on the waste loads and water use than does the size per se.

68

Size was considered as a possible factor for subcategorization but from analysis of the compiled data size, per se, does not justify categorization. Throughout the steel industry mills vary greatly in physical size, layout and product size. However, these considerations revealed no relationship to process water usage, discharge rate, effluent quality or any other pertinent factors.

69

Age as a factor might be expected to be at least amenable to quantitative identification and interpretation, but the extensive investigation of the industry does not indicate that age alone is a factor. The steel industry is old. Some of the old mills still incorporate early operating ideas and practices. However, other old mills are very new in that they have incorporated the latest operating ideas and practices.

70

Nevertheless, most older mills have been updated by internal changes in process, design, and equipment. Therefore, to say that a mill was built 50 years ago and is 50 years old is not particularly meaningful in terms of interpreting mill practices. In particular, no consistent pattern between mill age and raw waste characteristics was found. 41 Fed.Reg. 12993.

71

Contrary to the Companies' contentions, we believe that these passages in the interim final regulations, and others appearing at 41 Fed.Reg. 12992-5, demonstrate that the EPA did consider subcategorizing the iron and steel industry on the basis of factors other than manufacturing processes. Moreover, the Companies have not suggested that the record shows that there is an insufficient factual basis for the EPA's treatment of the subcategorization question. As EPA concedes, the chosen subcategorization like any subdivision of the industry does not take into account all of "the innumerable differences within the particular subcategories." AISI I, 526 F.2d at 1046. But this does not in itself imply that the EPA has failed to properly exercise its functions under the FWPCA.

72

We must, however, agree with the Companies' contention that, to the extent it considered age as a relevant factor, the EPA did not consider age as it might pertain to the cost or feasibility of retrofitting plants with new pollution control technology, as required by this court's decision in AISI I,526 F.2d at 1048. As in the previous case, the interim final regulations recite that the EPA has found that age per se is not relevant to factors such as type of pollutants produced. But the EPA has not specifically found that age has no bearing on the cost or feasibility of retrofitting plants with pollution control technology, and a finding on this issue is mandated by our earlier decision.

73

The interim final regulations recite that the concept of plant age is not amenable to interpretation because "most older mills have been updated by internal changes in process, design, and equipment. Therefore, to say that a mill was built over 50 years ago and is 50 years old is not particularly meaningful in terms of interpreting mill practices." In its brief, EPA suggests that this is a sufficient answer to the retrofit question: age has little or no bearing on retrofit because the concept of plant age itself is difficult to define.

74

Were we writing on a clean slate, we might find this argument convincing. But since the facts in this case cannot be properly distinguished from the facts in the earlier case we must reject EPA's contention. The discussion of the bearing of age and size in the interim final regulations does not differ in material respects from EPA's discussion of this issue in the regulations which were reviewed in the previous case. Compare 39 Fed.Reg. 24116 with 41 Fed.Reg. 12993, 13002. EPA argues that new data submitted to it after the earlier regulations were remanded "substantiates (its) conclusion and obviates the need for further investigation." But again, the interim final regulations do not expressly address the retrofit problem. EPA also argues that a study by Arthur D. Little, Inc., which was commissioned by AISI, reinforces the Agency's findings, since this study states that:

75

"(i)n the iron and steel industry it is difficult to define the age of a plant, because many of the unit operations were installed at different times and are also periodically rebuilt on different schedules. Thus, by definition, the age of steel facilities should offer only limited benefits as a means of categorizing plants for purposes of standard setting or impact analysis."

76

But the Companies are not bound to accept the conclusion that age is not relevant to cost or feasibility of retrofit merely because of any conclusion contained in a report commissioned by AISI. They have a right, under our earlier decision, to a finding on the retrofit question by the EPA. We note, however, that we have not dismissed the EPA's resolution of the retrofit question on the merits: we merely require that the Agency reexamine the relevance of age specifically as it bears on retrofit. As this court said in AISI I, 526 F.2d at 1048: "(i)f (EPA) concludes on remand that age is not relevant to the cost or feasibility of retrofitting plans (sic), as well as to the processes and treatment system, that conclusion will be valid to the extent it is supported by the record." We note that the reconsideration of the bearing of age on the cost or feasibility of retrofitting plants shall include consideration of standards setting within subcategories as well as altered subcategorization.

77

3. The Companies have also questioned the EPA's approach to determining BPCTCA within the subcategories. After EPA had decided upon a subcategorization of the industry, it determined the BPCTCA for each of these subcategories by calculating the average waste load at the exemplary plants, and "visualiz(ing)" a treatment model for attaining the calculated effluent load. In visualizing a treatment scenario, the EPA arrived at a projected effluent flow, given an "achievable" concentration level. But it is important to emphasize that the interim final regulations do not require the use of treatment technologies with these particular flow and concentration levels. Indeed, the industry is free to employ any treatment technology it chooses, as long as this technology enables the industry to attain the prescribed level of effluent load.

78

The Companies insist that determining BPCTCA by arriving at a maximum permissible load of effluents and "visualizing" a control technology which would meet these limitations is working backward: they argue that EPA should have first examined the technology in existence and then estimate how much this technology can contribute toward cleaning up effluent. We must reject this argument. In the first place, in visualizing control technologies, EPA specified measures which it had found were used in plants in each subcategory. We do not mean to imply that the EPA is always bound to select technologies already in place for BPCTCA: indeed, the legislative history of the FWPCA would seem to indicate that the EPA is not so restricted.16 But the fact remains that the EPA did select technology already in place in some plants for BPCTCA. Moreover, the EPA performed a cost-benefit analysis on the technology it selected through the challenged procedure, and this is ultimately what is required by the FWPCA. As long as EPA has performed the cost-benefit analysis required by the Act, and has selected a type of technology which may, under the Act, be a BPCTCA, it is irrelevant that it selected the BPCTCA by visualizing a control technology that would achieve desired effluent limitations.

79

The Companies also argue that the EPA's approach of determining the BPCTCA after calculating the average effluent load at the best plants in each subcategory "permitted (it) to derive limitations from effluent samples without analyzing how these particular treatment levels could be achieved at other plants, or investigating why they were not being (met) by other plants." But this argument really amounts to a claim that it was "necessarily an abuse of discretion to base the regulations on results obtained from a few plants which were using the best technology" a claim which was rejected in AISI I, 526 F.2d at 1057. It is true that as long as EPA focuses only on some plants in each subcategory there is a possibility that some differences between plants in the subcategory may be ignored: not all plants within a subcategory are perfectly typical of all plants within the subcategory even once the industry has been subcategorized in a permissible manner. But petitioners have not made an adequate showing that the plants EPA surveyed do not constitute an adequate sampling of the subcategories they represent.

80

4. The Companies assert that the EPA's cost estimates are defective because they fail to take into account costs for such factors as land acquisition, site clearance, utility interconnection between battery limits and process equipment, sales and use taxes, freight charges, supporting utility requirements such as boilers, instrumentation other than that for pH and fluoride control, and safety systems. They also stress that the Agency's assumptions as to the characteristics of the sites on which plants are located were unrealistic, and that these assumptions thus caused the Agency's cost figures to be inaccurate.

81

EPA argues that the Companies' contention is satisfactorily disposed of by the following passage from this court's opinion in AISI I :

82

A troublesome question is presented by petitioners' contention that the costs estimated by the Administrator were artificially low because certain factors were excluded. Petitioners point to the fact that the Final Development Document listed several factors which admittedly affected costs, but which were excluded from the cost analysis. Petitioners contend that these factors, which include such things as land acquisition and site clearance costs, generate costs which are as large as those which the Administrator included in his estimates. However, petitioners have pointed to no data which would support their allegation as to the magnitude of these excluded costs factors. Furthermore, many of these factors were excluded because they were inherently site-specific or because they could not be evaluated. For these reasons, we do not believe we can conclude that the exclusion of these factors from the costs analysis was arbitrary or capricious. 526 F.2d at 1053. (footnotes omitted).

83

The present case, however, is different from the situation presented in AISI I in two significant respects. First, the Companies have pointed to record data in the EPA's study of plants in Ohio's Mahoning River Valley which substantiates their claim that these costs are indeed significant. Second, as to whether the costs in question can be evaluated, EPA has presented in its brief a procedure for comparing its "generous" estimates of cost factors other than site-specific factors with the actual total (including site-specific) costs of reporting plants which meet or exceed the BPCTCA standards.

84

The EPA also argues that its treatment of site-specific costs was adequate because it did in fact include an adequate allowance for these costs. The ANPR states that:

85

The most accurate way to determine the water pollution control facility costs and the site specific costs would be to calculate these costs for each operation at each of the many mills and plants. Such a determination is far beyond the scope of this effort and thus a method approximating these costs was developed. The contractor was conservative in estimating both the treatment facilities required to achieve the effluent quality and the cost of these facilities. This is borne out by the data submitted by the companies, relative to the plants visited which were meeting the proposed guidelines (Forming and Finishing Segment), shows that these plants on the average experienced total installation costs (Facility costs plus site-specific costs) and annual operating costs less than the facility costs alone (i. e., not including site specific costs) or the operating costs as estimated by the study contractor. For this analysis actual costs reported were adjusted to August 1971 dollars to be consistent with the costs used by the study contractor. An adjustment was made also to achieve consistency in the production capacity of the actual facility and the typical facility for which the treatment models were costed out. 40 Fed.Reg. 36724.

86

But while EPA asserts that its contractor's cost estimates were, on the average, adequate to cover site-specific factors, we are not directed to record evidence which would permit us to verify that the Agency actually employed the procedure set forth in its brief or another procedure to compare its model cost estimates with the actual total (including site-specific) costs of reporting plants which meet or exceed the BPCTCA standards. Indeed, EPA's brief demonstrates that in several subcategories, the costs predicted from the model diverge significantly from the actual cost data from reporting plants. The case will thus be remanded for appropriate consideration of the factors originally not included by the Agency. See EPA's Development Document for the Interim Final Regulations at 526-8. To the extent that the sufficiency of the allowance for certain factors which were excluded may not be adequately checked using the procedure presented in EPA's brief or another procedure, the Agency may continue to exclude these factors.

87

5. The Companies contend that the EPA did not adequately consider the industry's ability to find the funds necessary to install and operate the pollution control equipment required to achieve the effluent limitations specified in the interim final regulations. As EPA states in its brief, its analysis of the economic impact of its regulations is based upon its analysis of a study by Temple, Barker and Sloane, Inc. (TBS). The following data from the TBS report indicates the magnitude of the burdens EPA's regulations will impose on the industry.

88

Long run (1975-83) capital expenditures required to comply with the BPCTCA regulations now under review total $1.39 billion (all figures in 1975 dollars); $0.96 billion will be required for operations and maintenance of this equipment over the same period. On the other hand, the capital for capacity expansion and modernization sufficient to meet anticipated steel shipment requirements and to be able to operate at planned levels of utilization comes to $27.50 billion over the period 1975-83. Revenues required to comply with the BPCTCA effluent limitations in the present regulations come to $2.59 billion for the period 1975-83, while $338.61 billion will be needed for baseline17 requirements associated with the production of iron and steel. TBS anticipates that $1.11 billion of the revenues required over the 1975-83 period to finance pollution control must come from external sources of funds, while $12.99 billion in external financing will be needed for baseline expenditures associated with iron and steel manufacturing.

89

The extent of the burden imposed upon the industry is underscored by TBS' statement that:

90

"(d)uring the last decade the steel industry has depended upon external sources for less than $1.0 billion . . . Thus, the steel industry must attract significant amounts of capital to finance expansion and modernization of steel operations after more than a decade of negligible financing activity. Environmental regulations will increase these financing requirements."

91

Moreover, TBS noted that the industry's ability to attract sufficient capital was diminished by the fact that:

92

. . . the industry's level of profitability has seriously lagged the average of all manufacturing with the exception of 1974 when the relaxation of price controls and worldwide shortages of both steel and basic raw materials enabled the steel industry to raise its prices and fully utilize its productive capacity. Overall steel industry rates of return in 1974 equalled the all-manufacturing average, with natural resources extraction and some non-steel activities (e.g., chemicals) far exceeding the returns on steel operations. Over the last decade, however, the steel industry's rate of return on common equity has averaged one-half of that for all manufacturing firms when profitability is adjusted to reflect inflationary trends.

93

The Companies have made several challenges to the Agency's consideration of the financing problem. But we need consider only one: that the Agency relied on a February draft of the TBS report, which contains significant differences from the report dated as of March the month in which the interim final regulations were promulgated. The February draft states that:

94

(I)t is TBS's opinion that the steel industry would be unable to finance its expansion, modernization and pollution control requirements without earning an adequate return on common equity at least equal to that realized by steel firms overall. Difficulties in financing these needs would be eased further if steel firms could achieve a return equal to other manufacturing firms. (emphasis added)

95

On the other hand, the March report states that:

96

"(i)t is TBS's opinion that the steel industry will be unable to finance its expansion, modernization and pollution control requirements without earning a rate of return on common equity at least equal to those realized by other manufacturing firms." (emphasis added)

97

As EPA concedes before this Court, the "projected average nominal return on equity for the steel industry equals 72% Of the projected average nominal return on equity by the manufacturing sector as a whole." Thus, we cannot consider the difference between the February draft of the TBS study and the March report merely as a change in emphasis or of verbal shading. Nor can we consider the subject of the conditions under which the industry can meet all of its financing needs as peripheral to TBS' basic conclusions. Thus, unless the differences between the drafts of the TBS report are irrelevant because EPA made a sufficient independent assessment of the financing problem, or unless we can infer that the EPA was aware of and considered the March report, we must remand the matter to the Agency for reconsideration of the financing problems raised by the interim final regulations. If the Agency based its assessment of the financing problem in substantial part on the assumption that it had the benefit of TBS' expertise in evaluating the problem, and it did not in fact have the benefit of TBS' ultimate conclusions, the regulations must be viewed as having been promulgated under a misimpression going to the heart of the Agency's exercise of discretion.

98

As to whether the EPA did make a sufficient independent assessment of the financing problem, it is important to note the following disclaimer in the March TBS report:

99

This report is being released and circulated at approximately the same time as publication in the Federal Register of a notice of proposed and interim final rule making under sections 304(b) and 306 of the Act for the subject point source category. The study is not an official EPA publication. It will be considered along with the information contained in the Development Document and any comments received by EPA on either document before or during rule making proceedings necessary to establish final regulations. Prior to final promulgation of regulations, the accompanying study shall have standing in any EPA proceeding or court proceeding only to the extent that it represents the views of the contractor who studied the subject industry. It cannot be cited, referenced, or represented in any respect in any such proceeding as a statement of EPA's views regarding the subject industry.

100

Moreover, the Agency has argued before us that it "not only reviewed the TBS text but also analyzed the underlying data which remained unchanged." However, several factors lead us to conclude that EPA did rely in substantial part on TBS' expertise in evaluating the industry's financing problem, and not simply on the data contained in the report.

101

In the first place, EPA itself belittles the "standard" disclaimer contained in the March TBS report. Moreover, after completing a survey of the conclusions (rather than merely the data) contained in the March report, EPA's brief states that "(t)he soundness of the TBS report and the Administrator's reliance thereupon are clearly supported in the record." We also note that the "Summary Economic Analysis of Effluent Guidelines for the Integrated Iron and Steel Industry" dated February 6, 1976, which was the last full discussion of the financing problem actually prepared by the Agency,18 states that: "(t)he summary of economic effects that follows is prepared from preliminary results (of the TBS study) . . . This report summarizes the study in terms of the effects of the effluent guidelines on internal and external costs." The "Summary Economic Analysis" states that its "baseline assumption" is that the industry will be able to earn "approximately a 9% Return on stockholder equity." As the Agency itself notes, the 9% Figure is the projected rate of return on equity for the steel industry, (the rate stressed in the February TBS draft) rather than the manufacturing sector as a whole. In sum, we conclude that the EPA did rely on TBS' expertise in evaluating the extent of the financing burden imposed by the interim final regulations.

102

But we cannot infer that EPA ever received or considered the contents of the March draft of the TBS report. The Agency's own "Summary Economic Analysis," as we have noted, is dated February 6, 1976. Moreover, the interim final regulations state that:

103

Studies of the economic impact of these regulations are under way and will be reported in the near future as separate reports entitled "Economic Analysis of Effluent Guidelines, Iron and Steel Industry" and "Economic Analysis of Effluent Guidelines, Specialty Steel Industry". 41 Fed.Reg. 13001.

104

The March TBS report is entitled "Economic Analysis of Proposed and Interim Final Effluent Guidelines, Integrated Iron and Steel Industry."

105

The matter is remanded to the Agency for reconsideration of the financing problems raised by the interim final regulations.

106

6. The Companies argue that the EPA did not adequately consider the evidence that combined treatment of waste streams ("central treatment") should be adopted as BPCTCA. The interim final regulations state that:

107

The comment has been made that these limitations require individual waste treatment facilities at each operating unit and prohibit the use of central waste treatment facilities which are more economical to construct and to operate.

108

Central treatment facilities typically provide for equalization, neutralization, solid removal, and sludge dewatering. Other pollutants requiring removal are usually more efficiently and economically controlled or recovered by a pretreatment step applied to the segregated stream. These regulations have been constructed so as to permit a discharger to apply either approach.

109

In the event that waste streams from various sources are combined for treatment or discharge, the quantity of each pollutant or pollutant property attributable to each controlled waste source (subcategories M through V) shall not exceed the specified limitation for that particular waste source. For example, if a plant's production allows it to discharge 5 lbs. a day of tin from its terne plating operation, it would not be allowed to discharge 10 lbs. a day of tin because the terne line wastes were combined with cold rolling wastes for treatment.

110

However, in the instance of the use of pickling wastes to assist in the breaking of emulsified oils from cold rolling wastes, some added waste load discharges are permitted by the regulation. The cost savings that could be achieved by the use of one waste stream to treat another waste stream was considered sufficient to justify permitting additional loads to be discharged. 41 Fed.Reg. 13002.

111

The nature of EPA's decision with respect to central treatment can fairly be inferred from this passage. EPA recognized that the use of central treatment facilities could result in significant savings, but was concerned that combining different waste streams would sometimes increase the total load of pollutants discharged because some pollutants would be diluted and thus made more difficult to treat. The Agency consequently provided that when waste streams are combined, no more pollutant load can be discharged than if the streams had been segregated. However, the Agency recognized that in one instance combined treatment of cold rolling and pickling wastes some added waste load discharge should be allowed. The Agency also concluded that, in some cases, some of the benefits of central treatment could be attained by incorporating a pretreatment step to remove such wastes as would be unduly diluted before combining waste streams for central treatment. While we believe that the Agency could have set forth its reasoning on the cost-benefit question with greater clarity, we conclude that the record shows that it did give adequate consideration to the use of central treatment.

112

The Companies argue that many steel facilities are so crowded and have such limited land available that it is simply impracticable to employ separate treatment. They cite one of the plants studied by EPA's contractor as an example of a plant where central treatment could be impracticable. There may be some individual plants with extraordinary space limitations or other problems; these plants may petition the permit granters for a variance from the nationwide standards under the variance clause of EPA's regulations. But the companies have failed to show that the EPA's conclusions as to central treatment are unreasonable with respect to the industry as a whole. They have not argued that EPA's cost estimates assume central treatment, and thus make insufficient allowances for the measures which would have to be taken to institute separate treatment. Moreover, with respect to land availability, the interim final regulations state that: "(i)t is recognized that at older mills, the mill buildings may be crowded together, so the technologies suggested for . . . BPCTCA minimize land requirements." 41 Fed.Reg. 12993.

113

7. The Companies also claim that the EPA based its regulations on effluent flow rates which are too restrictive and unrealistic. Again, we must note that the interim final regulations do not require a particular flow rate: industry may employ any combination of concentrations and flow rates which achieves the prescribed effluent loads. Nevertheless, it is true that the EPA's assumption about the effluent flow rates was relevant to its choice of BPCTCA, and thus to the ultimate § 301 effluent limitations as well, since the flow rate is relevant to the type of technology to be employed, and thus to the costs.

114

The Companies' first challenge to the EPA's treatment of flow rates is that the Agency ignored comments to the contractor's report and to the ANPR which indicated that the data base was unduly narrow and that the data from some of the sampled plants was incorrect. However, we are not directed to any evidence in the record which would substantiate these charges. Moreover, we note that a report of the EPA's Iron and Steel Task Force, which was established after the ANPR, states that the group reexamined the data base on the basis of further information "from the plants." As to the Hot-Forming-Primary subcategory, the report states specifically that "(t)he data base was examined and revised to include company data (particularly as regards flows) . . . "

115

The Companies next challenge the flow rates on which the regulations are based because EPA employed a "circular" procedure in determining them. According to the Companies, the flows were calculated by multiplying flow by concentration to achieve the "calculated" loading, and then dividing by concentration to give the flow on which the regulations were based. This, however, is a misleading portrayal of the actual procedure. EPA set the hypothesized flow on which its choice of BPCTCA was based by first calculating the average discharge load at the best plants in each subcategory, and then dividing by what it considered to be the lowest concentration of pollutant materials which facilities could be relied on to attain. This is hardly a circular procedure even though the "calculated" loading of the best plants might be arrived at by multiplying the flow rate at each plant by the discharge rate at this plant.

116

The Companies argue that the flow rates required by the BPCTCA are unrealistically low. We note, however, that plants in each of the subcategories mentioned by them now have flow rates lower than those hypothesized by EPA as a basis for the interim final regulations.

117

We also reject the Companies' assertion that recycle of effluent cannot be BPCTCA because it requires facilities to make extensive internal alterations. The legislative history of the 1972 amendments to the Water Pollution Control Act shows that Congress expected the EPA to base BPCTCA standards chiefly upon end-of-manufacturing treatment of wastewater, though courts which have considered the problem have concluded that Congress did not intend to preclude the EPA from basing its BPCTCA standards on in-process control measures, at least when these measures are "considered normal practice within the industry." FMC Corp. v. Train, 539 F.2d 973, 981 (4th Cir. 1976); see also American Petroleum Institute v. E.P.A., 540 F.2d 1023, 1033 (10th Cir. 1976); American Paper Institute v. Train, 177 U.S.App.D.C. 181, 194, 543 F.2d 328, 341 (1976); Hooker Chemicals & Plastics Corp. v. Train, 537 F.2d 620, 637 (2d Cir. 1976). The Report of the House Committee is instructive as to Congress' intent that BPCTCA consist, for the most part, of secondary treatment: "(b)y the term 'control technology' the Committee means the treatment facilities at the end of a manufacturing . . . or other process rather than control technology within the manufacturing process itself."19

118

We agree with EPA that recycling of effluent does not constitute a change "within the manufacturing process itself." Rather, it is one form of secondary treatment, since it consists of gathering effluent from existing manufacturing processes, treating it, and returning the treated liquid to the process.

119

Some elucidation of the distinction between secondary treatment and in-process controls may be gathered from the legislative history of § 306 of the Act, which concerns national standards of performance for new sources of pollution. The Conference Committee Report states that under § 306 "that the Administrator is required to establish standards of performance which reflect the levels of control achievable through improved production processes, and of process technique, etc."20 The House Committee's Report states that in setting standards for new sources, the EPA must look both "to control technology and procedures and operating methods inside the production plant."21 With respect to recycling of effluent, the fact that some plants in the industry may have to substantially alter their piping and sewer systems does not mean that recycle is an in-process control. The dislocation of manufacturing processes which these alterations may cause is not the same thing as a change in "operating methods."

IV.

120

We next take up an issue posed by the Sierra Club and Pennsylvania's Department of Environmental Resources, petitioners22 in Nos. 76-1749 and 76-1751: whether the EPA's decision to exempt plants in the Mahoning River Valley from effluent limitations requiring the application of BPCTCA was proper under the FWPCA.

121

Several arguments have been advanced to support the contention that the exemption is invalid. However, we need address only one: that the EPA is not permitted to exempt polluters from point source limitations established under the Act.

122

Section 301(e) of the FWPCA states that: "Effluent limitations established pursuant to this section or section 302 of this Act shall be applied to all point sources of discharge of pollutants in accordance with the provisions of this Act." Section 301 effluent limitations, as we have noted, require facilities to discharge no more than a specified quantity of pollutant. See E. I. duPont de Nemours and Company v. Train, 430 U.S. 112, 97 S.Ct. 965, 51 L.Ed.2d 204 (1977). Section 302 is not relevant here.23 So in this case § 301(e) requires the EPA to establish specific effluent limitations under § 301 for all point sources of discharge.

123

EPA, however, has exempted point sources located in the Mahoning Valley region "from the effluent limitations based on best practicable control technology currently available." EPA claims that its decision:

124

. . . does not exempt those plants from coverage by the National Pollutant Discharge Elimination System (NPDES) permits issued pursuant to FWPCA Section 402.24 Neither does it exempt those facilities from the application of State laws and regulations, including water quality standards for the Mahoning River. The decision does not define current discharge as "best practicable control technology currently available" for those plants, and it does not mean that discharges from those plants will remain at their current level. The Administrator's decision means solely that "best practicable control technology currently available" for those facilities must be defined and effluent limitations must be established and applied on a case-by-case basis by the State of Ohio. (footnote omitted)

125

This argument fails to address the specific command of § 301(e), namely, that effluent limitations established under § 301 be applied to all point sources.25

126

EPA also argues that the legislative history of the Water Pollution Control Act Amendments of 1972 shows that while Congress was concerned with national uniformity of effluent standards, it recognized the need to allow flexibility in the federal pollution control system in order to accommodate the diverse conditions found across the country. We do not dispute this contention because we hold solely that, under § 301(e), an exemption by regulation from effluent limitations is not a permissible means of accommodating diversity.26

127

We conclude that the decision to exempt plants in the Mahoning Valley from the § 301 effluent limitations is invalid, and remand to the EPA for reconsideration of the problems underlying its initial decision to grant plants in the Mahoning Valley special treatment. In remanding the case for this purpose, we wish to emphasize that we do not decide whether the FWPCA allows the Agency to afford special treatment on the basis of location, rather than explicitly and directly on the basis of identified factors which could conceivably be exhibited by plants located anywhere in the country.

V.

128

Petitioner in No. 76-2232, CF&I Steel Corporation ("CF&I"), contends that the EPA did not adequately consider a "non-water quality environmental impact" which it alleges must be considered under the FWPCA namely, the scarcity of water resources in the arid and semi-arid regions of the country. 33 U.S.C. § 1314(b)(1)(B). The water scarcity problem allegedly arises because the recycle technologies specified as BPCTCA for some subcategories require companies to use a system for cooling effluent before it can feasibly be reused in the process. The majority of cooling systems allegedly cause a greater water loss through evaporation than would occur in a system where effluent is disposed of directly into navigable waters.

129

We agree with CF&I's contention that water scarcity is a non-water quality environmental factor which the EPA must consider. See Appalachian Power Co. v. Train, 545 F.2d 1351, 1368-71 (4th Cir. 1976). CF&I's first argument27 that the EPA did not adequately consider this factor is based on the claim that the Agency, in promulgating the present phase of the regulations, failed to consider the aggregate impact on water resources of phase I of the regulations, which we reviewed in AISI I, and regulations on thermal discharges which might be set forth by the Agency in the future, in addition to the water loss due to phase II itself. CF&I relies on this Court's Statement in AISI I, with respect to the actual economic costs of meeting the prescribed limitations, that:

130

. . . we are concerned that the Administrator be required at some point to assess the overall impact of his regulations in both phases. Otherwise, it is possible that the Administrator might consider the costs reasonable for each phase separately, without ever considering whether the aggregate costs on a particular industry warrant such strict standards. We thus believe that the competing interests can best be served by requiring the Administrator, when he promulgates the phase II regulations, to evaluate the total costs involved for those regulations as well as for phase I regulations. 526 F.2d at 1054.

131

EPA argues that it did in fact consider the aggregate impact of phase I and II. We find this contention devoid of support in the record. But we are persuaded by EPA's alternative contention that our earlier decision does not require it to consider the aggregate impact of phase I, phase II, and possible regulations on thermal pollution when promulgating phase II itself. Our earlier decision was addressed to the cumulative burdens the different phases of the regulations would impose on a "particular industry." Here, on the other hand, we are asked to require EPA to scrutinize the cumulative burdens its regulations would place on the water resources of entire areas of the country. We decline to extend the statement in our earlier decision to cover factors other than those which pertain to the aggregate burden placed on a "particular industry." We cannot conclude that it is arbitrary or capricious of EPA to consider the water scarcity problem by comparing the benefits in pollution reduction attributable to each phase of its regulations with the loss in water resources attributable to that phase.

132

CF&I also contends that EPA did not adequately consider the water loss problem posed by phase II alone. The discussion of the water loss problem in the interim final regulations is as follows:

133

One commenter stated that no consideration was given to the destructive use of water and that excessive recycle, particularly at the BATEA level, results in the unnecessary destruction of water.

134

A means to dissipate heat is frequently a necessity if a recycle system is to be employed. The evaporation of water in cooling towers or from ponds is the most commonly employed means to accomplish this. However, fin-tube heat exchangers or dry type cooling towers can be used to achieve cooling without evaporation of water. Such systems are used in the petroleum processing and electric utilities industries (see page 543, . . . Development Document for Effluent Limitations Guidelines and New Source Performance Standards for the Steam Electric Power Generating Point Source Category.)

135

The Agency also feels that recognition of the evaporation of water in recycle systems (and hence loss of availability to potential downstream users) should be balanced with recognition that evaporation also occur (sic) in once through systems, when the heated discharge causes evaporation in the stream. This is not an obvious phenomenon, since it occurs downstream of the discharge point, but to the downstream user it is as real as with consumptive in-plant usage, because assuming that the stream eventually gets back to temperature equilibrium with its environment, it will get there primarily by evaporation, i. e., with just as certain a loss of water. Additionally, the use of a recycle system permits lessening the intake flow requirements. 41 Fed.Reg. 13003.

136

CF&I focuses on the Agency's statement that "fin-tube heat exchangers or dry type cooling towers can be used to achieve cooling without evaporation of water." It argues that the Agency did not give adequate consideration to the possibility that severe scaling and fouling problems would develop if such closed cooling systems were used in the iron and steel industry. CF&I also challenges the Agency's reliance on its Development Document for Effluent Limitations Guidelines and New Source Performance Standards for the Steam Electric Power Generating Point Source Category, claiming that the EPA failed to adequately explore differences between the iron and steel industry and the steam electric power generating industry.

137

The EPA first responds that "the Agency was and is of the view that no cooling devices of any kind will be employed to meet Phase II BPT." (emphasis added) We must reject this response because it is not sufficiently reconcilable with the EPA's statement in the interim final regulations that: "(a) means to dissipate heat is frequently a necessity if a recycle system is to be employed." EPA also argues that fin-tube heat exchangers or dry type cooling towers are applicable to waters which do not contact steel as it is being formed and finished, even if these cooling systems are not applicable to contact cooling water. But the regulations state that "fin-tube heat exchangers or dry type cooling towers can be used to achieve cooling without evaporation of water." They do not distinguish between contact and non-contact cooling waters. Moreover, EPA has conceded that: "(s)ince iron and steel industry process (contact) waters may be more prone to fouling and scaling than steam electric cooling water, the Steam Electric Development Document does not directly support EPA's belief that dry type cooling towers could be utilized on steel industry process waters without fouling and scaling problems."

138

In sum, even inferring that EPA considered the fouling and scaling problem, we must conclude that there is insufficient evidence to support the statement in the interim final regulations that "fin-tube heat exchangers or dry type cooling towers can be used to achieve cooling without evaporation of water." Since EPA may have proceeded under a mistaken assumption of fact as to the water loss attributable to the interim final regulations, the matter will be remanded to the Agency for further consideration of whether fin-tube heat exchangers or dry type cooling towers may be employed despite any fouling or scaling problems assuming that cooling systems of some kind will be employed in order to meet the effluent limitations prescribed in the regulations. Since fouling and scaling problems may also extend to other types of cooling systems mentioned in the Development Document for the steam electric power generating industry, the Agency will consider any fouling and scaling problems associated with the use of these systems.

139

In addition, the Court notes that the various cooling systems mentioned in the Development Document for the steam electric power generating industry including basin cooling, basin cooling with sprays, wet cooling towers, and wet/dry cooling towers as well as dry cooling towers result in widely divergent evaporation rates. Thus, the cost in terms of water loss of achieving the specified effluent limitations may vary greatly depending on which cooling system is employed, assuming that a cooling system is required to achieve the effluent limitations based on BPCTCA. However, the record does not show that the EPA, in concluding that the specified effluent limitations were not too costly in terms of water consumption, was of any particular view as to how often each of the different cooling systems would be used.

140

We conclude that the Agency may not decline to estimate the water loss due to the interim final regulations as accurately as possible on the grounds that, whatever the cost in water consumption, the specified effluent limitations are justified. In order to insure that the Agency completes a sufficiently specific and definite study of the water consumption problem on remand, the Agency must address the question of how often the various cooling systems will be employed, or present reasons why it cannot make such an assessment.28

VI.

141

The petitions to review the interim final regulations are denied, except as follows:

142

1. The regulations are invalid for want of proper notice insofar as they apply to the specialty steel industry.

143

2. The interim final regulations are remanded to the Agency for a finding as to the bearing of "age" on the cost or feasibility of retrofitting plants with pollution control technology.

144

3. To the extent applicable, the regulations are remanded to the Agency to enable it to make a record showing that it has made adequate allowance for certain cost factors which were originally not directly included.

145

4. The regulations are remanded to the Agency for reconsideration of the industry's financing problems.

146

5. The Agency decision to exempt plants in the Mahoning River Valley from the § 301 effluent limitations is invalid and the matter is remanded to the Agency for appropriate reconsideration.

147

6. To the extent applicable, the regulations are remanded to the Agency for further consideration of whether fin-tube heat exchangers or dry type cooling towers may be employed despite any fouling or scaling problems assuming that cooling systems of some kind will be employed. Similar consideration should be given to these problems as they may be associated with the use of other cooling systems which might be employed.

148

The Agency on remand shall also consider the question of the extent the various cooling systems will be employed or present reasons why such an assessment is not feasible.

149

In closing this opinion, we must note that we have been troubled by the Agency's apparent failure to objectively identify the entire record of its action at the time of its original decision. We strongly suggest that the Agency adopt measures to correct this situation, so that the reviewing court is not faced with the problem of determining what materials were indeed before the Agency at the time of its decision.

*

H. Curtis Meanor, United States District Judge for the District of New Jersey, sitting by designation

1

We reject as meritless petitioners' claim that the EPA violated the APA by failing to consider comments they made during the formulation of these regulations

2

Basic Oxygen Furnace-Wet Air Pollution Control Methods Subcategory (Subpart G); Vacuum Degassing Subcategory (Subpart K); and Continuous Casting and Pressure Slab Molding Subcategory (Subpart L)

3

We need not, and do not, discuss possible circumstances under which the pendency of a court order to promulgate regulations might constitute "good cause" for dispensing with notice and an opportunity for comment. See National Resources Defense Council, Inc. v. Train, 166 U.S.App.D.C. 312, 331, 510 F.2d 692, 711 n.103 (1975)

4

We may not hold that the regulations are valid because they are in interim final form, with provision that the Agency will "consider petitions for reconsideration of any permits" issued under the regulations if the "final regulation differs substantially" from the interim finals. 41 Fed.Reg. 13004. The regulations are to take effect immediately, and we have no assurance that the possibility of petitioning the Agency for reconsideration of permits is sufficient to alleviate the likelihood of prejudice

5

The EPA also revised the regulations as to other subcategories. We have examined the notice with respect to all subcategories and find it sufficient

6

The BPCTCA specified for Subpart P (Pipe and Tubes Subcategory) calls for recycling of clarifier effluent, rather than the effluent which has only passed through the scale pit as with Subparts M, N and O

7

Environmental Policy Division of the Library of Congress, A Legislative History of the Water Pollution Control Act Amendments of 1972, 93d Cong., 1st Sess. (Comm. Print 1973), at 1468 (hereinafter, "Leg.Hist.")

8

40 Fed.Reg. 36712

9

40 Fed.Reg. 36711-13

10

We cannot accept the Companies' claim that the ANPR could not serve to fulfill the notice of requirement because it was, in terms, "advance notice of intent to propose and promulgate" regulations. The ANPR served the function of inviting comments on the issues before the Agency because it stated that:

This advance notice of proposed rulemaking is being issued pursuant to EPA's policy for early rulemaking proceedings to provide the interested public a greater opportunity for review and comment . . . The purpose, therefore, in giving this advance notice is to apprise interested persons of EPA's expected course of action, and to provide such interested persons with an opportunity to submit comments thereon.

In addition, this advance notice is given so as to obtain the aforesaid comments in sufficient time to enable EPA to promulgate effluent limitations guidelines and pretreatment standards by December 1, 1975, in accordance with the order of the United States District Court for the District of Columbia in Natural Resources Defense Council, Inc. v. Russell E. Train . . . 40 Fed.Reg. 36708.

11

We find no merit to Pennsylvania's claims that: a) the ANPR did not sufficiently specify that the Agency might consider granting special treatment to facilities in the Mahoning Valley b) the Agency had a duty to defer notice and comment until after it had completed its investigation and proposed a modification to the regulatory scheme c) that it was denied effective participation in the rulemaking process

12

See AISI I, 526 F.2d at 1047

13

Leg.Hist. at 170

14

Leg.Hist. at 1466

15

Development Document for Interim Final Effluent Limitations Guidelines and Proposed New Source Performance Standards for the Forming, Finishing and Specialty Steel Segments of the Iron and Steel Manufacturing Point Source Category, at 145

16

Senator Muskie's statement in support of the 1972 amendments to the FWPCA as approved by the House-Senate Conference Committee says that: "(i)n those industrial categories where present practices are uniformly inadequate, the Administrator should interpret 'best practicable' to require higher levels of control than any currently in place if he determines that the technology to achieve those higher levels can be practicably applied." Leg.Hist. at 169-70

17

The March TBS report indicates that "baseline" conditions represent "anticipated future operating conditions . . . (excluding) the impact of all pending environmental regulations . . . (but including) the impact of pollution control equipment placed into service prior to 1975."

18

A February 17, 1976 "Briefing Outline" on economic effects by EPA's staff does not mention what rate of return on equity the industry must earn. But this fact does not persuade us that the statement of the required rate of return in the fuller "Summary Economic Analysis" was peripheral to its conclusions, that EPA did not rely substantially on TBS' expertise in evaluating the extent of the financing problem, or that EPA considered the March TBS report

19

Leg.Hist. at 788

20

Leg.Hist. at 311

21

Leg.Hist. at 798

22

Sierra Club has standing because its members in Ohio and Pennsylvania will allegedly be adversely affected "in their aesthetic, recreational and conservational interests, and in their personal health and well-being, by the water pollution which the subject regulations unlawfully permit to continue." See United States v. SCRAP, 412 U.S. 669, 93 S.Ct. 2405, 37 L.Ed.2d 254 (1973)

Pennsylvania's Department of Environmental Resources has standing because some of its citizens, in the Beaver Falls area, utilize the Mahoning River as a public water supply.

23

Section 302 allows the Agency to establish "effluent limitations" (including alternative effluent control strategies) when, in its judgment, § 301 limitations would not adequately assure the "attainment or maintenance of (adequate) water quality in a specific portion of the navigable waters." 33 U.S.C. § 1312

24

For a description of the states' role in developing and carrying out permit programs under § 402, see the Supreme Court's decision in E. I. duPont de Nemours and Company v. Train, supra

25

The Report of the House Committee on Public Works states, with reference to § 301(b), that it "requires that all point sources of discharge of pollutants . . . achieve . . . effluent limitations requiring the use of the best practicable control technology currently available." Leg.Hist. at 787 (emphasis added)

26

We do not accept EPA's suggestion that our decision is contrary to National Resources Defense Council v. Train, 166 U.S.App.D.C. 312, 331, 510 F.2d 692, 711 n.102 (1975), where the Court said that: "(w)e do not believe that the statute requires guidelines covering all point sources." The same footnote states that: "the statute does not prohibit the promulgation of effluent limitations for point sources in the absence of guidelines."

27

Portions of CF&I's brief call into question the reasonableness of the Agency's determination that the regulations do not result in undue water loss. In view of our disposition of the case, we need not consider this question

We reject CF&I's contention that the regulations are invalid because the Agency did not sufficiently consider the water law and policy of the western United States. See AISI I, 526 F.2d 1027, 1050 n.49.

28

In view of the fact that we have remanded the interim final regulations in other respects, we do not consider EPA's suggestion that we limit our remand on the water loss problem only "to point sources not located in arid or semi-arid regions."